In consequence of my inability in cotton-picking, Epps was in the habit of hiring me out on sugar plantations during the season of cane-cutting and sugar-making. He received for my services a dollar a day, with the money supplying my place on his cotton plantation. Cutting cane was an employment that suited me, and for three successive years I held the lead row at Hawkins’, leading a gang of from fifty to an hundred hands.
In a previous chapter the mode of cultivating cotton is described. This may be the proper place to speak of the manner of cultivating cane.
The ground is prepared in beds, the same as it is prepared for the reception of the cotton seed, except it is ploughed deeper. Drills are made in the same manner. Planting commences in January, and continues until April. It is necessary to plant a sugar field only once in three years. Three crops are taken before the seed or plant is exhausted.
Three gangs are employed in the operation. One draws the cane from the rick, or stack, cutting the top and flags from the stalk, leaving only that part which is sound and healthy. Each joint of the cane has an eye, like the eye of a potato, which sends forth a sprout when buried in the soil. Another gang lays the cane in the drill, placing two stalks side by side in such manner that joints will occur once in four or six inches. The third gang follows with hoes, drawing earth upon the stalks, and covering them to the depth, of three inches.
In four weeks, at the farthest, the sprouts appear above the ground, and from this time forward grow with great rapidity. A sugar field is hoed three times, the same as cotton, save that a greater quantity of earth is drawn to the roots. By the first of August hoeing is usually over. About the middle of September, whatever is required for seed is cut and stacked in ricks, as they are termed. In October it is ready for the mill or sugar-house, and then the general cutting begins. The blade of a cane-knife is fifteen inches long, three inches wide in the middle, and tapering towards the point and handle. The blade is thin, and in order to be at all serviceable must be kept very sharp. Every third hand takes the lead of two others, one of whom is on each side of him. The lead hand, in the first place, with a blow of his knife shears the flags from the stalk. He next cuts off the top down as far as it is green. He must be careful to sever all the green from the ripe part, inasmuch as the juice of the former sours the molasses, and renders it unsalable. Then he severs the stalk at the root, and lays it directly behind him. His right and left hand companions lay their stalks, when cut in the same manner, upon his. To every three hands there is a cart, which follows, and the stalks are thrown into it by the younger slaves, when it is drawn to the sugar-house and ground.
If the planter apprehends a frost, the cane is winrowed. Winrowing is the cutting the stalks at an early period and throwing them lengthwise in the water furrow in such a manner that the tops will cover the butts of the stalks. They will remain in this condition three weeks or a month without souring, and secure from frost. When the proper time arrives, they are taken up, trimmed and carted to the sugar-house.
In the month of January the slaves enter the field again to prepare for another crop. The ground is now strewn with the tops, and flags cut from the past year’s cane. On a dry day fire is set to this combustible refuse, which sweeps over the field, leaving it bare and clean, and ready for the hoes. The earth is loosened about the roots of the old stubble, and in process of time another crop springs up from the last year’s seed. It is the same the year following; but the third year the seed has exhausted its strength, and the field must be ploughed and planted again. The second year the cane is sweeter and yields more than the first, and the third year more than the second.
During the three seasons I labored on Hawkins’ plantation, I was employed a considerable portion of the time in the sugar-house. He is celebrated as the producer of the finest variety of white sugar. The following is a general description of his sugar-house and the process of manufacture:
The mill is an immense brick building, standing on the shore of the bayou. Running out from the building is an open shed, at least an hundred feet in length and forty or fifty feet in width. The boiler in which the steam is generated is situated outside the main building; the machinery and engine rest on a brick pier, fifteen feet above the floor, within the body of the building. The machinery turns two great iron rollers, between two and three feet in diameter and six or eight feet in length. They are elevated above the brick pier, and roll in towards each other. An endless carrier, made of chain and wood, like leathern belts used in small mills, extends from the iron rollers out of the main building and through the entire length of the open shed. The carts in which the cane is brought from the field as fast as it is cut, are unloaded at the sides of the shed. All along the endless carrier are ranged slave children, whose business it is to place the cane upon it, when it is conveyed
